Gasket Moto
![]() |
![]() ATHENA TOP END GASKET KIT YAMAHA BADGER MOTO RAPTOR 80 US $38.92
|
![]() ATHENA TOP END GASKET KIT YAM TRACKER MOTO WOLF 225 250 US $43.71
|
![]() ROTAX SKI DOO MOTO SKI 346 F A 73 75 COMP GASKET SET US $29.99
|
Many mini moto modifications will require you to remove the engine from the mini moto. This is why I have produced the following guide.
Firstly you will need to remove the mini moto's fairing.
Start with the seat fairing, unscrew the four seat screws and remove the seat. Unscrew the screw at the front end of the seat fairing and remove the petrol cap. The fairing can now be lifted from the mini moto. Replace the fuel tank petrol cap and remove the fuel tank by pulling the rubber tube of the nipple on the top of the carburettor. You may want to double the rubber fuel tube over and secure it in this position with a clothes peg. This is to stop fuel leaking out.
Remove the bottom fairing by unscrewing the holding bolts (two on each side), this frees the bottom fairing from the top. Unscrew the two bolts on the underside of the bottom fairing. The bottom fairing is now free. The top fairing is only now held on by one last bolt located in between the handle bars at the front of the mini moto.
Once you have removed the fairing, you will need to take the chain off the front sprocket. To do this loosen the back wheel nuts and the tensioning bolts. The back wheel can now be manoeuvred toward the front sprocket loosing the chain. When the chain is loose enough you can remove it from the front sprocket.
Remove the pull start from the engine by unscrewing the three holding screws. Once the pull start has been removed you will see the wire that comes from the stop switch. Unplug this.
The throttle cable can be removed from its fitting on the top of the carburettor. Pull the rubber seal up so that the locking nut can be unscrewed, the throttle can now be pulled from the carburettor along with the needle valve and spring.
The next step is to Remove the Exhaust. The exhaust is fixed to the mini motos frame by a bolt located just under the seat fairing toward the back of your mini moto. Undo this bolt with a spanner and an alan key. The exhaust is fixed to the underside of the engine by two bolts via a gasket. Remove the two bolts with an alan key making sure that you do not lose the gasket washer. The exhaust can now be slid out past the engine and removed form the mini moto.
The engine is free from its mechanical fittings, the engine then needs to be removed from the mini motos frame. The bolt at the top of the engine must be undone first using the alan key. The three screws located on the underside of the engine are the last fixings to be undone. The engine can now be completely removed from the mini moto.
Matt Tong has been importing and riding Mini Motos for two years. For expert advice and Mini Moto information please visit http://www.minimotosandmore.com [http://www.germany-2006-worldcup.com]
|
|
Moto $10 Moto - United Fun |
|
|
Moto Stunts $10 Moto Stunts - Patrick Stephens |
|
|
Moto-Submarine $39.99 Moto-Submarine - Giclee Print |
|
|
Crazy Moto $10 Crazy Moto - United Fun Traders |
|
|
Salamanca Moto $189.99 Gracia Salamanca Moto - Giclee Print |
|
|
Moto Sacoche $32.99 Joe Bridge Moto Sacoche - Art Print |
|
|
Moto Ultima $32.99 Chris Flanagan Moto Ultima - Art Print |
|
|
Gibraltar Hydraulic Moto Throne $139.99 Gibraltar Hydraulic Moto Throne |
|
|
dav Women's Moto Boot $47.2 dav Women's Moto Boot |
|
|
Moto 1 2005 $13.99 Moto 1 2005 |
|
|
Mr Moto on Danger Island $11.99 Mr Moto on Danger Island |
|
|
Mr Moto Takes A Chance $11.99 Mr Moto Takes A Chance |
|
|
Mr Moto Takes A Vacation $11.99 Mr Moto Takes A Vacation |
|
|
Mr Moto's Gamble $11.99 Mr Moto's Gamble |
|
|
Mr Moto's Last Warning $11.99 Mr Moto's Last Warning |
|
|
Thank You Mr Moto $11.99 Thank You Mr Moto |
|
|
The Mysterious Mr Moto $11.99 The Mysterious Mr Moto |
|
|
Think Fast Mr Moto $11.99 Think Fast Mr Moto |
|
|
Moto X Evolution of Trick $17.99 Moto X Evolution of Trick |
|
|
Moto Guzzi V7 $24.99 Moto Guzzi V7 - Photographic Print |
|
|
Permatex HighTemp Red RTV Silicone Gasket 81160 $25.81 Gasket |
|
|
Moto Socks $14.99 EVS Moto Socks Reinforced heel and toe for long lasting durability Extra tall for added comfort under knee protection |
|
|
Screw Kit for Moto Kneeguard $5.4 Replacement screws for Fly Racing Moto Kneeguards |
|
|
Paparazzi (Moto Blanco Remix) $6 Paparazzi (Moto Blanco Remix) - Lady GaGa |
|
|
Moto Guzzi GP Dustbin $59.99 Moto Guzzi GP Dustbin - Giclee Print |
|
|
Ultima Moto Lyon Motorcycle $124.99 Ultima Moto Lyon Motorcycle - Framed Giclee Print |
|
|
Grateful Dead- Moto Sam $27.99 Grateful Dead- Moto Sam - T-Shirt |



US $154.99

































































































